2 0 0 7
VOLVO
S60

Specifications

pg. 197 Specifications

Label information 198
Dimensions and weights 200
Capacities 202
Engine oil 203
Fluids and cooling system 204
Three way catalytic converter 205
Suspension 206
Electrical system 207
Engine specifications 209
Volvo programs 210

All specifications are subject to change without prior notice.

pg. 198 Specifications

Label information

pg. 199 Specifications

Label information

1. Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery, etc.

2. Child safety lock labels1

3. Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) standards (Canada)
Your Volvo is designed to meet all applicable safety standards, as evidenced by the certification label on the facing side of the driver's door. For further information regarding these regulations, please consult your Volvo retailer.

4. Loads and Tire Pressures
The appearance of the decal will vary, depending on the market for which the vehicle is intended.

  • Canadian models: upper decal
  • U.S. models: lower decal

    5. Vehicle Identification Number (VIN)
    The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door pillar.
    The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle with the retailer and when ordering parts.

    6. Vehicle Emission Control Information/ Vacuum hose routing
    Your Volvo is designed to meet all applicable emission standards, as evidenced by the certification label on the underside of the hood. For further information regarding these regulations, please consult your Volvo retailer.

    1. Not on vehicles equipped with the optional power child safety locks.

    pg. 200 Specifications

    Dimensions and weights

    Dimensions
    Length 180 in. (458 cm)
    S60R - 181.7 in. (462 cm)
    Width 71 in. (180 cm)
    S60R - 71 in. (180 cm)
    Height 56.2 in. (143 cm)
    S60R - 55.7 in. (142 cm)
    Wheelbase 107 in. (272 cm)
    Front track 61.5 in. (156 cm)
    Rear track 61.4 in. (156 cm)
    Turning circle 35.4-38.7 ft.
    (10.8-11.8 m)
    S60R: 42.7 ft (13 m)
    Cargo capacity, trunk SAE V1 - 13.9 (394)

    Max. loads
    Max. roof load 220 lbs (100 kg)
    Max. trailer weight:
    - without brakes
    - with brakes, 2" ball1
    - with brakes, 1 7/8" ball

    1650 lbs (750 kg)
    3300 lbs (1500 kg)
    2000 lbs (900 kg)
    Max. tongue weight: 165 lbs (75 kg)
    Trailer weights below 2,650 lbs (1,200 kg) 110 lbs (50 kg)
    Trailer weights above 2,650 lbs (1,200 kg) 165 lbs (75 kg)

    1. When driving for prolonged periods at temperatures above 86 °F (30 °C), the maximum recommended weight is 2000 lbs (900 kg).

    See also page 131 for additional information.

    warningWARNING!

    When adding accessories, equipment, luggage and other cargo to your vehicle, the total capacity weight must not be exceeded.

    pg. 201 Specifications

    Dimensions and weights

    Weights
    AWD = All Wheel Drive
    Gross vehicle weight1 USA Canada
    5-cyl. turbo manual 4430 lbs 2010 kg
    5-cyl. turbo automatic 4470 lbs 2030 kg
    5-cyl turbo AWD automatic 4540 lbs 2060 kg
    5-cyl turbo AWD-R manual/automatic 4540 lbs 2060 kg
    Capacity weight
    5-cyl. turbo 870 lbs 395 kg
    5 cyl. turbo AWD 805 lbs 365 kg
    5 cyl. turbo AWD-R 770 Ibs 350 kg
    Permissible axle weights, front1
    5-cyl. turbo 2400 lbs 1090 kg
    5-cyl. turbo AWD automatic 2420 lbs 1100 kg
    5-cyl. turbo AWD-R manual 2400 lbs 1090 kg
    5-cyl. turbo AWD-R automatic 2420 lbs 1100 kg
    Permissible axle weights, rear1
    5-cyl., 5-cyl. turbo 2220 lbs 1010 kg
    5-cyl. turbo AWD, AWD-R 2310 lbs 1050 kg
    Curb weight
    5-cyl. turbo 3430-3505 lbs 1545-1580 kg
    5-cyl. turbo AWD 3560-3595 lbs 1620-1640 kg
    5-cyl. turbo AWD-R 3660-3735 lbs 1680-1700 kg

    1. Permissible axle weight or gross vehicle weight must never be exceeded.

    pg. 202 Specifications

    Capacities

    Fuel tank: 18 US gal. (68 liters)

    Transmission fluid
    Manual (M 66) 2.1 US qts. (2.0 liters)
    Automatic (AW 55-50) 7.6 US qts. (7.2 liters)
    Automatic (TF-80SC) S60 R 7.4 US qts (7.0 liters)

    Miscellaneous
    Power steering 0.9 US qts. (0.9 liters)
    Windshield washer reservoir 4.8 US qts. (4.5 liters)
    Brake and clutch fluid 0.69 US qts. (0.65 liters)
    Air conditioning system 2.2 lbs. (1 kg) R 134a
    Windshield washer reservoir 6.8 US qts (6.4 liters)
    S60 R 4.8 US qts (4.5 liters)

    pg. 203 Specifications

    Engine oil

    Engine oil
    Engine oil must meet the minimum ILSAC specification GF-3, API SL, and ACEA A1/ B1. Lower quality oils may not offer the same fuel economy, engine performance, or engine protection.

    Volvo recommends.

    Volume
    Engine designation Volume between MIN-MAX on dipstick Volume1
    B5254T4
    B5254T2
    B5244T5
    1.3 US qts (1.2 liters) 5.8 US qts. (5.5 liters)

    1. Including filter replacement

    pg. 204 Specifications

    Fluids and cooling system

    Fluids
    Transmission1

    Oil grade
    Manual: MTF 97309
    Automatic:
    AW5
    TF-80SC (S60R)

    JWS 3309
    JWS 3309

    Different types of oil should never be mixed.

    Power steering
    Grade:
    Volvo synthetic power steering fluid (Pentosin CHF 11S) P/N 1161529 or equivalent.

    Brake fluid
    Fluid type:
    DOT 4+ boiling point >536°F (280°C).

    Cooling system
    Type Positive pressure, closed system.
    Coolant Volvo original coolant/ antifreeze
    Volume 9.3 US qts (8.8 liters)

    The thermostat begins to open at 194°F (90°C).

    1. The transmission oil does not normally need to be changed during the service life of the vehicle. However, it may be necessary to replace the oil if the vehicle is often driven in areas of sustained temperature extremes (hot or cold), when towing a trailer over long distances, for prolonged driving in mountainous areas, or if the vehicle is often driven short distances in temperatures under 40°F (5°C).

    pg. 205 Specifications

    Three way catalytic converter

    Three-way catalytic converter cautions

  • Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or distributor ignition systems, may cause unusually high three-way catalytic converter temperatures. Do not continue to operate your vehicle if you detect engine misfire, noticeable loss of power or other unusual operating conditions, such as engine overheating or backfiring. A properly tuned engine will help avoid malfunctions that could damage the three-way catalytic converter.
  • Do not park your vehicle over combustible materials, such as grass or leaves, which can come into contact with the hot exhaust system and cause such materials to ignite under certain wind and weather conditions.
  • Excessive starter cranking (in excess of one minute), or an intermittently firing or flooded engine can cause three-way catalytic converter or exhaust system overheating.
  • Remember that tampering or unauthorized modifications to the engine, the Electronic Control Module, or the vehicle may be illegal and can cause three-way catalytic converter or exhaust system overheating. This includes:
    - Altering fuel injection setting or components.
    - Altering emission system components or location or removing components.
    - Repeated use of leaded fuel.

    NOTE: Unleaded fuel is required for vehicles with three-way catalytic converters.

    pg. 206 Specifications

    Suspension

    Rear suspension
    Individual rear wheel suspension with longitudinal support arms, double link arms and track rods.

    Front suspension
    Spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Power-assisted rack and pinion steering. Safety type steering column.

    pg. 207 Specifications

    Electrical system

    Bulbs
    Bulbs Type Socket
    High beam H9 65W  
    Low beam H11 55W  
    Active Bi-Xenon headlight (option) 65W D1S
    Front foglights H1 55 
    Front foglights (S60 R) H3 55W  
    Front/rear parking lights,
    front side marker lights,
    rear footwell lighting,
    license plate lighting
    W5W W2.1x9.5d
    Front/rear turn signals (amber) PY21W BAU15s
    Side turn signals WY5W W2.1x9.5d
    Brake lights, backup lights,
    rear foglight
    P21W BA15s
    Rear parking light P21/4W BAZ15d
    Rear parking light R5W BA15s
    Rear side marker light R10W BA15s
    License plate lighting WW5 SV8.5
    Front footwell lighting,
    cargo area lighting
    C5W SV8.5
    Vanity mirror 1.2W SV5.5

    warningWARNING!

    Active Bi-Xenon headlights (option) - due to the high voltage used by these headlights, these bulbs should only be replaced by an authorized Volvo service technician.

    pg. 208 Specifications

    Electrical system

    12-volt system with voltage controlled generator. Single wire system in which the chassis and engine block are used as conductors, grounded on the chassis.

    Battery
    Voltage: 12 V
    Cold start capacity (CCA): 600 A
    Reserve capacity (RC): 115 min
    Capacity (Ah): 70
    If you must replace your battery, be sure to replace it with a battery of the same cold start capacity and reserve capacity as the original (See the decal on the battery).

    Generator
    Max. current: 140 A

    Starter motor
    Power: 1.4 kW

    Spark plugs
    P/N272313-8 or equivalent
    Gap: 0.028-0.032 in. (0.7-0.8 mm)
    Tightening torque: 22 ft. lbs. (30 Nm)
    Firing order: 1-2-4-5-3

    warningWARNING!

    The distributor ignition system operates at very high voltages. Special safety precautions must be followed to prevent injury. Always turn the ignition off when:

  • Replacing distributor ignition components e.g. plugs, coil, etc.
  • Do not touch any part of the distributor ignition system while the engine is running. This may result in unintended movements and body injury.
  • pg. 209 Specifications

    Engine specifications

     
    Engine designation
    Specification B5244T5 B5254T2 B5254T4
    Output (kW/rps) 191/92 154/83 220/921
    Output(hp/rpm) 257/5500 208/5000 300/55001
    Torque (Nm/rps) 330/42-87 320/25-75 400/31-952
    Torque(ft. lbs./rpm) 258/2100-5000 236/1500-4500 295/1950-52502
    No. of cylinders 5 5 5
    Bore (in./mm) 3.19/81 3.19/81 3.27/83
    Stroke (in./mm) 3.67/93.2 3.67/93.2 3.67/93.2
    Cylinder displacement (l) 2.4 (146.5 cu in) 2.52 (153.8) 2.52 (153.8)
    Compression ratio 8.5:1 9.0:1 8.5:1

    1. Automatic transmission: 220 kW at 100 rps, 300 hp at 6000 rpm.
    2. Automatic transmission: 350Nm at 32-100 rps, 258 ft. lbs at 1850-6000 rpm.

    Charge air cooler (Intercooler)
    Turbocharged engines employ a turbocompressor to force air into the engine inlet manifold and a charge air cooler to cool the compressed inlet air. The resulting increase in air flow raises pressure in the intake manifold and increases engine power over that developed by the normally-aspirated engine. The charge air cooler (which resembles a radiator) is located between the turbo-compressor and inlet manifold.

    Fuel system
    The engine is equipped with a multiport fuel injection system.

    pg. 210 Specifications

    Volvo programs

    Volvo On Call Roadside Assistance
    Your new Volvo comes with a four year ON CALL roadside assistance. Additional information, features, and benefits are described in a separate information package in your glove compartment.
    If you have misplaced your package, dial:
    In the U.S.A.:
    1-800-638-6586 (1-800-63-VOLVO)
    In Canada:
    1-800-263-0475

    Technician certification
    In addition to Volvo factory training, Volvo supports certification by the National Institute for Automotive Service Excellence (A.S.E.). Certified technicians have demonstrated a high degree of competence in specific areas. Besides passing exams, each technician must also have worked in the field for two or more years before a certificate is issued. These professional technicians are best able to analyze vehicle problems and perform the necessary service procedures to keep your Volvo at peak operating condition.



    Previous Page   Next Page

    Contents | Top of Page