2 0 0 7
VOLVO
S40

224
 11 Specifications

Label information226
Dimensions and weights228
Engine oil231
Engine specifications233
Electrical system234
Volvo programs236

225
 11 Specifications

226
 11 Specifications

Label information

227
 11 Specifications

Label information

1. Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery, etc.

2. Child safety lock
This information is stamped on the rear inside edges of the doors.

3. Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) standards (Canada)
Your Volvo is designed to meet all applicable safety standards, as evidenced by the certification label on the facing side of the driver's door. For further information regarding these regulations, please consult your Volvo retailer.

4. Loads and Tire Pressures
The appearance of the decal will vary, depending on the market for which the vehicle is intended.
Canadian models: upper decal
U.S. models: lower decal

5. Vehicle Identification Number (VIN)1
The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door pillar.

6. Vehicle Emission Control Information/Vacuum hose routing
Your Volvo is designed to meet all applicable emission standards, as evidenced by the certification label on the underside of the hood. For further information regarding these regulations, please consult your Volvo retailer.

1 The Vehicle Identification Number (VIN) should always be quoted in correspondence concerning your vehicle with the retailer and when ordering parts.

228
 11 Specifications

Dimensions and weights

Dimensions

1 38.4 cu. ft. (1088 liters) with the front passenger's seat backrest folded down (certain models only).

CAUTION
The maximum permissible axle loads and/ or the gross vehicle weight must not be exceeded.

warning WARNING
When adding accessories, equipment, luggage and other cargo to your vehicle, the total capacity weight must not be exceeded.

229
 11 Specifications

Dimensions and weights

Weights

1FWD = Front Wheel Drive

2AWD = All Wheel Drive

3Models equipped with the B5244S7 engine (engine code 39, which is the 6th and 7th digits from the left in your vehicle's VIN number, see page 227 for the location of the VIN plate), may not be used to tow trailers or vehicles of any kind. This could cause damage to the vehicle's emission control systems.

230
 11 Specifications

Dimensions and weights

Specifications and capacities

note NOTE
The transmission oil does not normally need to be changed during the service life of the vehicle. However, it may be necessary to replace the oil if the vehicle is often driven in areas of sustained temperature extremes (hot or cold), when towing a trailer over long distances, for prolonged driving in mountainous areas, or if the vehicle is often driven short distances in temperatures under 40°F (5°C).

231
 11 Specifications

Engine oil

Oil specifications

Engine oil must meet the minimum ILSAC specification GF-3, API SL, and ACEA A1/B1. Lower quality oils may not offer the same fuel economy, engine performance, or engine protection.

Volume: 6.1 US qts (5.8 liters).

Volume between the MIN and Max marks on the dipstick: approximately 1.4 US qts (1.3 liters).

Volvo recommends .

Depending on your driving habits, premium or synthetic oils may provide superior fuel economy and engine protection. Consult your Volvo retailer for recommendations on premium or synthetic oils.

Oil additives must not be used.

note NOTE
Synthetic oil is not used when the oil is changed at the normal service intervals. This oil is only used at customer request, at additional charge. Please consult your Volvo retailer.

Oil viscosity (stable ambient temperatures)

Operation in hot climates
When temperatures exceed 86° F (30° C) in your area, Volvo recommends, for the protection of your engine, that you use a heavier weight oil, such as such as SAE 5W-40 or 0W-40. See the viscosity chart.

Operation in temperate climates
Incorrect viscosity oil can shorten engine life. Under normal use when temperatures do not exceed 86° F (30° C), SAE 5W-30 will provide good fuel economy and engine protection. See the viscosity chart.

Extreme engine operation
Synthetic oils meeting SAE 0W-30 or 0W-40 and complying with oil quality requirements are recommended for driving in areas of sustained temperature extremes (hot or cold), when towing a trailer over long distances, and for prolonged driving in mountainous areas.

1 See the information on page 232.

232
 11 Specifications

Engine oil

American Petroleum Institute (API) symbol
The API Service Symbol "donut" is divided into three parts:

  • The upper section describes the oil's performance level.
  • The center identifies the oil's viscosity.
  • The lower section indicates whether the oil has demonstrated energy-conserving properties in a standard test in comparison to a reference oil.

    233
    		 11 Specifications

    Engine specifications

    1 The engine specifications for horsepower and torque listed in this table are based on the use of premium fuel.

    Charge air cooler (Intercooler)
    Turbocharged engines employ a turbo-compressor to force air into the engine inlet manifold and a charge air cooler to cool the compressed inlet air. The resulting increase in air flow raises pressure in the intake manifold and increases engine power over that developed by the normally-aspirated engine. The charge air cooler (which resembles a radiator) is located between the turbo-compressor and inlet manifold.

    Fuel system
    The engine is equipped with a multiport fuel injection system.

    234
    		 11 Specifications

    Electrical system

    General information

    12-volt system with voltage controlled generator. Single wire system in which the chassis and engine block are used as conductors, grounded on the chassis.

    Bulbs
    Please refer to page 195 for a list of the bulbs used in your car.

    Battery

    1Models equipped with the High Performance audio system

    2Models equipped with the Premium Sound audio system, the Volvo Navigation System and/or keyless drive

    If the battery must be replaced, replace it with one with the same cold start capacity and reserve capacity as the original (see the decal on the battery).

    warning WARNING
    PROPOSITION 65 WARNING!
    Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the state of California to cause cancer and reproductive harm. Wash hands after handling.

    235
    		 11 Specifications

    Electrical system

    Three-way catalytic converter - general information

  • Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or distributor ignition systems, may cause unusually high three-way catalytic converter temperatures. Do not continue to operate your vehicle if you detect engine misfire, noticeable loss of power or other unusual operating conditions, such as engine overheating or backfiring. A properly tuned engine will help avoid malfunctions that could damage the three-way catalytic converter.
  • Do not park your vehicle over combustible materials, such as grass or leaves, which can come into contact with the hot exhaust system and cause such materials to ignite under certain wind and weather conditions.
  • Excessive starter cranking (in excess of one minute), or an intermittently firing or flooded engine can cause three-way catalytic converter or exhaust system overheating.
  • Remember that tampering or unauthorized modifications to the engine, the Electronic Control Module, or the vehicle may be illegal and can cause three-way catalytic converter or exhaust system overheating.
    This includes:
    - Altering fuel injection settings or components.
    - Altering emission system components or location or removing components.
    - Repeated use of leaded fuel.

    note NOTE
    Unleaded fuel is required for vehicles with three-way catalytic converters.

    236
    		 11 Specifications

    Volvo programs

    Volvo On Call Roadside Assistance

    Your new Volvo comes with a four year ON CALL roadside assistance. Additional information, features, and benefits are described in a separate information package in your glove compartment. If you have misplaced your package, dial:
    In the U.S.A. 1-800-638-6586 (1-800-63- VOLVO)
    In Canada: 1-800-263-0475

    Technician certification

    In addition to Volvo factory training, Volvo supports certification by the National Institute for Automotive Service Excellence (A.S.E.). Certified technicians have demonstrated a high degree of competence in specific areas. Besides passing exams, each technician must also have worked in the field for two or more years before a certificate is issued. These professional technicians are best able to analyze vehicle problems and perform the necessary maintenance procedures to keep your Volvo at peak operating condition.

    237
    		 11 Specifications

    This page left intentionally blank.


    Previous Page   Next Page

    Contents | Top of Page