2 0 0 2
VOLVO
S80

Chapter 9 - Specifications


pg. 123 Specifications



Label information 124
Dimensions and weights 125
Engine/transmission specifications 126
Oil/fluid specifications and volumes 127
Fuel system, Distributor ignition system, Suspension 128
Electrical system 129
Volvo On Call 130

pg. 124 Label information



1 Vehicle Emission Control Information

Your Volvo is designed to meet all applicable emission standards, as evidenced by the certification label on the underside of the hood. For further information regarding these regulations, please consult your Volvo retailer.

2 Vacuum hose routing
(underside of hood)

3 Loads and Tire Pressures
(on inside of fuel filler door)

4 Model plate

Vehicle Identification Number (VIN). Codes for color and upholstery, etc. The plate is located in the engine compartment, on the inside of the left front fender.

5 Vehicle Identification Number (VIN) *

The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door pillar.

6 Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) standards (Canada)

Your Volvo is designed to meet all applicable safety standards, as evidenced by the certification label on the facing side of the driver's door. For further information regarding these regulations, please consult your Volvo retailer.

7 Child safety latch label

* The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle with the retailer and when ordering parts.

All specifications are subject to change without prior notice.

pg. 125 Dimensions and weights



Dimensions
Length 189.8 in. (482 cm)
Width 72 in. (183 cm)
Height 57.1 in. (145 cm)
Wheelbase 109.8 in. (279 cm)
Track, front 62.2 in. (158 cm)
Track, rear 61.4 in. (156 cm)
Turning circle (between curbs) 35.8 - 39 ft. (10.9 - 12 m)
Cargo capacity - trunk 14.2 cu. ft. (0.4 m3)

Weights

USA Canada
Gross vehicle weight (GVW)
6 cyl. 4608 lbs 2090 kg
6 cyl. turbo 4670 lbs 2120 kg
Capacity weight *
6 cyl. 890 lbs 400 kg
6 cyl. turbo 890 lbs 400 kg
Curb weight
6 cyl. 3535-3570 Ibs 1605-1625 kg
6 cyl. turbo 3655-3685 Ibs 1635-1650 kg
Permissible axle weight, front
6 cyl. 2491 Ibs 1130 kg
Permissible axle weight, rear
6 cyl. 2293 lbs 1040 kg
Max roof load 220 lbs 100 kg
Max trailer weight
(w/o brakes) 1100 lbs 500 kg
Max trailer weight
(with brakes)
2" ball 3300 lbs 1500 kg
1 7/8" ball 2000 lbs 900 kg
Max tongue weight ** 165 lbs 75 kg

WARNING!

When adding accessories, equipment, luggage and other cargo to your vehicle, the total loaded weight capacity of the vehicle must not be exceeded.

* The max permissible axle loads or the gross vehicle weight must not be exceeded.

** See also section "Trailer towing"

All specifications are subject to change without prior notice.

pg.126 Engine/transmission specifications



Engine specifications
Designation: Volvo B 6284 T
Output 268 hp at 5200 rpm (200 KW/87 rps)
Max torque 280 ft. lbs. at 1800-5000 rpm (380 Nm at 35-83 rps)
Number of cylinders 6
Bore 3.27" (83 mm)
Stroke 3.54" (90 mm)
Displacement 2.92 liters (115 cu. in.)
Compression ratio 8.5:1
Number of valves 24

Charge air cooler (Intercooler)

Turbocharged engines employ a turbocompressor to force air into the engine inlet manifold and a charge air cooler to cool the compressed inlet air. The resulting increase in air flow raises pressure in the intake manifold and increases engine power over that developed by the normallyaspirated engine. The charge air cooler (which resembles a radiator) is located between the turbocompressor and inlet manifold.
Designation: Volvo B 6294 S
Output 194 hp at 5200 rpm (147 KW/100 rps)
Max. torque 207 ft. lbs. at 3900 rpm (280 Nm at 65 rps)
Number of cylinders 6
Bore 3.27" (83 mm)
Stroke 3.54" (90 mm)
Displacement 2.92 liters (115 cu. in)
Compression ratio 10.5:1
Number of valves 24

Transmission specifications
Automatic transmission
Gear ratios:
Engine: B 6284 T B 6294 S
1st gear 2.92:1 3.27:1
2nd gear 1.57:1 1.76:1
3rd gear 1.00:1 1.12:1
4 th gear 0.70:1 0.79:1
Reverse 2.38:1 2.67:1
Final drive 3.29:1 3.69:1

All specifications are subject to change without prior notice.

pg. 127 Oil/fluid specifications and volumes



Engine oil

Meeting minimum ILSAC specification GF-2, including ACEA A1, API SJ, SJ/CF and SJ/Energy Conserving.

Extra oil additives must not be used unless advised by an authorized Volvo retailer.

Volume: (including filter):
Normally-aspirated 6-cylinder engine - 7.3 US qts (6.9 liters).
Turbo 6-cylinder engine - 7.3 US qts (6.9 liters).

Automatic transmission fluid

Geartronic: ATF Dexron® III.
AW5: Only Volvo gearbox oil (1161540-8). Do not mix with other oils.

Volume: 7.9 US qts (7.5 liters).

Cooling system

Type: Positive pressure, closed system. The thermostat begins to open at 194 °F (90 °C).
Coolant: Volvo original coolant/antifreeze.

Volume: Normally-aspirated 6-cylinder engine - 9.3 US qts (8.8 liters).
Turbo 6-cylinder engine - 10.1 US qts (9.6 liters).

Power steering fluid

ATF fluid.

Volume:6 cyl engine - 0.95 US qt (0.9 liter).

Brake fluid

DOT 4+ boiling point > 536°F (280° C) P/N 9437433

Volume: 0.6 US qt (0.6 liter)

Climate control system - refrigerant (R 134a)

Oil: PAG

Volume: 2.2 lbs (1000 g) R134a.

Fuel

Minimum octane requirement - AKI 87 (RON 91)

Volume (fuel tank): 21.1 US gals (80 liters)

Washer fluid reservoir

Volume: 6 cyl: 4.7 US qts. (4.5 liters)

All specifications are subject to change without prior notice.

pg.128 Fuel system, Distributor ignition system, Suspension



Fuel system

The engine is equipped with a multiport fuel injection system.

Distributor ignition system

Firing order: 15-3-6-2-4
Distributor ignition setting: Not adjustable
Spark plugs: B 6284 T: P/N 271367-4 (or equivalent)
B 6294 S: P/N 272371-8 (or equivalent)
Spark plug gap: 0.028-0.032" (0.7-0.8 mm)
Tightening torque: 18.4 ft. lbs. (25 Nm)

WARNING!

The distributor ignition system operates at very high voltages. Special safety precautions must be followed to prevent injury. Always turn the ignition off when:

· Replacing distributor ignition components e.g. plugs, coil, etc.

· Do not touch any part of the distributor ignition system while the engine is running. This may result in unintended movements and body injury.

Front suspension

Spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Powerassisted rack and pinion steering. Safety type steering column.

The alignment specifications apply to an unladen car but include fuel, coolant and spare wheel.

Toe-in measured on the wheel rims: 2.3 mm +/ 0.8 mm

Toe-in measured on tire sides: 2.8 +/ 0.9 mm

Rear suspension

Individual rear wheel suspension with longitudinal support arms, double link arms and track rods.

Toe-in measured on the tire sides: 1.9 mm +/ 1.9 mm

Vehicle loading

The tires on your Volvo should perform to specifications at all normal loads when inflated as recommended on the tire information label. The label is located on the inside of the fuel tank cover. The label lists both tire and vehicle design limits. Do not load your car beyond the load limits indicated.

WARNING!

Improperly inflated tires will reduce tire life, adversely affect vehicle handling and can possibly lead to failure resulting in loss of vehicle control without prior warning.

All specifications are subject to change without prior notice.

pg. 129 Electrical system



Electrical system

12 Volt, negative ground.

Voltagecontrolled generator. Singlewire system with chassis and engine used as conductors. Grounded on chassis.

Battery

Voltage: 12 Volt, capacity: 600 A/115 min.

The battery contains corrosive and poisonous acids. It is of the utmost importance that old batteries are disposed of correctly. Your Volvo retailer can assist you in this matter.

Generator

Rated output: max. current: 140 A

Starter motor:

Output: 1.7 kW

Bulbs
Bulb US no. Power Socket
Headlights
  High beam H7 55W -
  Low beam H7 55W -
Front parking lights/ 5W W 2.1x9.5d
Front direction indicators - 21 W BAU 15d
Front fog lights H1 55 W -
Side marker lights - 3 W W2.1x9.5d
Rear direction indicators - 21W BAU 15 s
Tail lights 67 5W/4cp BA 15 s
Brake lights 1156 21W/32cp BA 15 s
Backup lights 1156 21W/32cp BA 15 s
Rear fog light 1156 21W/32cp BA 15 s
License plate light - 5 W W 2.1x9.5d
Door step courtesy lights
  Front - 5W SV 8.5
  Rear - 5W W 2.1x9.5d
Trunk lights - 10 W SV 8.5
Glove compartment light - 2 W BA 9s
Vanity mirror lights - 1.2 W SV 5.5
Instrument lighting - 3 W W 2.1x9.5d
Rear ashtray - 1.2 W W 2x4.6d
Front courtesy lights - 10 W SV 8.5
Rear reading lights - 5 W W2.1x9.5d
Sideview mirror - 5W W2.1x9.5d

All specifications are subject to change without prior notice.

pg. 130 Volvo On Call





Your new Volvo comes with a four year ON CALL road assistance. Additional information, features, and benefits are described in a separate information package in your glove compartment. If you have misplaced your package, dial:

In the U.S.A.

1-800-63-VOLVO (1-800-638-6586)

In Canada:

1-800-263-0475



Technician certification
In addition to Volvo factory training, Volvo supports certification by the National Institute for Automotive Excellence (A.S.E.). Certified technicians have demonstrated a high degree of competence in specific areas. Besides passing exams, each technician must also have worked in the field for two or more years before a certificate is issued. These professional technicians are best able to analyze vehicle problems and perform the necessary service procedures to keep your Volvo at peak operating condition.
All specifications are subject to change without prior notice.



Previous Page   Next Page

Contents | Top of Page