1 9 8 8
VOLVO
240

Before you drive

pg. 6 240 DL Sedan



pg. 7 Before you drive


Instruments and controls 8
Instruments 10
Warning lights 11
Clock, ambient temperature gauge 12
Oil pressure gauge, voltmeter 13
Ignition switch, turn signals 14
Lighting 15
Windshield wipers, washer nozzles 16
Washer fluid reservoir 17
Rear window demister, heated seat, hazard warning flasher 18
Parking brake 19
Cigarette lighter, ash trays 20
Electrically operated windows 21
Heating and ventilation 22
Air conditioning 24
Radios, AM-FM-FM stereo/tape players 25
Front seats 26
Seat belts 28
Doors and locks 30
Trunk lid 31
Hood release, long load storage 32
Rear/side view mirrors 33
Interior light, sun roof, fuel tank cap 34
Rear seat (wagon) 35
Tailgate (wagon) 36
Cargo compartment (wagon) 37

pg. 8 Instruments and controls




pg. 9 Instruments and controls


See page
1 Air louver 23
2 Turn signals 14
3 Headlights, parking lights 15
4 Instruments, lights 15
5 Instruments 10
6 Wiper/washer, taitgate window wiper/washer (wagon) 16, 17
7 Starting (ignition) switch/steering wheel lock 14
8 Air louver 23
9 Storage compartment (extra instrument or radio location) -
10 Air louver 23
11 Glove box -
12 Air louver 23
13 Fuse box 79
14 Hood release handle 32
15 Horn -
16 Cigarette lighter 20
17 Rear window demister 18
18 Hazard warning flashers 18
19 Air conditioning(some models) 24
20 Seat belt reminder light 28
21 Heating and ventilation 22
22 Gear lever or gear selector 43, 44
23 Ash tray 20
24 Fresh air louver(except models with air conditioning) 23
25 Radio receptacle 25
26 Fresh air louver 23
27 Electrically-operated windows (240 GL) 21
28 Control for electrically operated side mirrors (certain models only) -
29 Parking brake 19
30 Electrically-operated window, right front door (240 GL) 21
31 Seat belt release buttons 28
32 Seat heaters 19
33 Seat belt reminder light 24
34 Ash tray 20

The pages in this section provide a detailed description of the vehicle's instruments and controls.
Note that some vehicles may be equipped differently, depending on model, special legal requirements, etc.

pg. 10 Instruments

A Clock or Tachometer (depending on model)
Tachometer reads thousands of engine rpm. Engine should not be operated in red range.

B Direction indicator (green)

C Speedometer
In kilometers and miles per hour (U.S. models) In kilometers per hour (Canadian models)

D Odometer
Total reading in miles (U.S. models) Total reading in kilometers (Canadian models)

E Temperature gauge
The gauge pointer should remain Inside the black range during normal operation.

If the pointer enters the red range repeatedly, check coolant level and fan belt tension (See sections titled "Cooling system and coolant")

WARNING!
allow engine to cool before adding fluid.

Do not continue to drive the car with the pointer in the red zone.

F Fuel gauge
The fuel tank capacity is approx. 60 liters 15.8 US gals. See "Fuel requirements".

G Clock reset knob (DL)

H Service reminder light

I Alternator warning light (red)

J Oil pressure warning light (red)
Do not drive the car with this light on.

K Trip odometer reset knob
Push in to reset

L Trip odometer

M High beam indicator (blue)

N Parking brake reminder light (red)

O Brake failure warning light (red)

P Bulb failure warning light (yellow)

Q Overdrive OFF indicator light (yellow)
(automatic transmission models)

Shift indicator light (yellow)
(manual transmission models)

pg. 11 Warning lights

The warning lights described on this page should never be on when driving

When the ignition is turned on, and before the engine starts, all of the warning lights should be on to test the function of the bulbs. Should a light not go off after the engine has started, the system indicated should be inspected. (However, the parking brake reminder light will not go off until the parking brake is fully released.)


Alternator warning light (red)

If the light comes on while the engine is running, check the tension of the alternator drive belt as soon as possible. (See section titled "Cooling system".) NOTE: This warning light is illuminated if the alternator is not charging. However, alternator, parking brake, brake failure, and bulb failure will be illuminated at the same time due to the design of the system.

Oil pressure warning light (red)

If the light comes on during driving, the oil pressure is too low. Stop the engine immediately and check the engine oil level. See section titled "Engine Oil". Do not continue to drive the car with this light on.

After hard driving, the light will come on occasionally when the engine is idling. This is normal, provided it goes off when the engine speed is increased.

Parking brake reminder light (red)

This tight will be on when the parking brake (hand brake) is applied. The parking brake lever is situated between the front seats.

Brake failure warning light (red)

If the light comes on while driving and the brake pedal can be depressed further than normal, it is an indication that one of the brake circuits is not functioning. Stop immediately, open engine hood and check brake fluid level (see section "Brake fluid, power steering").
Reservoir empty: do NOT drive. Tow car to shop for check/repair of brake system. Reservoir not empty: proceed immediately and with caution to a Volvo dealer for an inspection of the brake system.

Bulb failure warning light (yellow)

The light will come on if any of the following bulbs are defective:
one of the lower beams
one of the tail tights
one of the brake lights (when the brake pedal is depressed).
See section on "Replacing Bulbs".

pg. 12 Service reminder light, Clock, Ambient temperature gauge


Service reminder light

This light will come on at 5,000 mile (8,000 km) intervals. It is a reminder to the driver that the 5,000 mile (8,000 km) service interval has been exceeded. The light will stay on 2 minutes after start until reset by the servicing dealer.


Quartz crystal clock

To reset the hands, push in the reset knob and turn.


Ambient temp. gauge (accessory)

An electronic thermometer that indicates ambient temperature just above the road surface. Warns you of icy road conditions

pg. 13 Oil pressure gauge, Voltmeter


Oil pressure gauge (accessory)

The oil pressure gauge indicates the pressure of the oil in the lubricating system of the engine. The pressure is dependent on the speed of the engine, the oil temperature and the viscosity of the oil.
The gauge pointer must not go down to the red field while driving.
Do not continue to drive the car with the pointer in the red zone.

Note: While idling with a hot engine the pointer may go into the red field. This is not a cause for concern providing the pointer rises to the normal driving range again when you increase the engine speed.


Voltmeter (accessory)

The voltmeter indicates the voltage in the electrical system and thereby also the state of the battery. While the car is being driven the pointer should be within the black field.
Should the pointer point to the upper or lower red field when driving, this may indicate some fault in the electrical system.

Note: While idling with a hot engine (especially with air conditioning ON), the pointer may indicate low voltage. This is not a cause for concern provided that the indicated voltage increases when you increase engine speed.

pg. 14 Starting (ignition) switch, Turn signals

Starting (ignition) switch/steering wheel lock


The steering wheel lock may be under tension when the car is parked. Turn the steering wheel slightly to free the ignition key.
A chime will sound if the starting key is in the ignition lock and the front door on the driver's side is open. The chime will also sound if the headlights or parking lights are on when the door is open.
The chime goes off when the front door is closed.


Turn signals

1 Signal lever engaged for normal turns.
Note:
A defective turn signal bulb will cause turn signal indicator and remaining signal lights to flash more rapidly than normal.

2 Lane change position. In maneuvers such as lane changing, the driver can flash the turn signals by moving the turn signal lever to the first stop and holding it there. The lever will return to the neutral position when released.


3 High and low beam switching (headlights on).
Move the lever towards the steering wheel and release it.
3 Headlight flasher (headlights off).
Move the lever towards the steering wheel. The headlight high beam will be on until the lever is released.

pg. 15 Lighting


Headlights and position lights
All lights off

Parking lights on

Headlights and parking lights on

Switch from upper to lower beams, and vice versa, by moving the turn signal switch lever on the left side of the steering column towards the steering wheel. The parking lights can be used without switching on the starting (ignition) key.


A chime will sound if the parking lights are on and the front door on the driver's side is open. The chime will also sound if the starting (ignition) key is in the switch lock when the door is open. The chime goes off when the driver's door is closed.
If the headlight is in position , all lights will go out when starting (ignition) switch is switched off.


Instrument panel lamps rheostat

Clockwise - brighter
Counterclockwise - dimmer.

pg. 16 Windshield wipers, Tailgate window wiper, Washer nozzles


Wiper/washer

1 Intermittent wiper.
With switch in this position, the wipers will make a stroke approx. every seventh second.

2 "Single stroke" position.
Switch returns automatically when released.

3 Wipers, low speed.

4 Wipers, high speed.

5 Windshield wiper/washer.
The wiper will make 2-3 complete stroking cycles after the lever is released.


Tailgate window wiper/washer, wagon
Operated by the switch at the end of the windshield wiper/washer operating lever.

1 Tailgate wiper

2 Interval position
With the switch in this position, there is one stroking cycle approx. every fifteen seconds.

3 Tailgate washer
Depress the button to start the-wiper/washer. The wiper will complete 2-3 stroking cycles after the button is released.


Adjusting washer nozzles
The fluid spray may be adjusted by carefully inserting a needle into the metal nozzle and rotating nozzle to desired position.

4-8" = 10-20 cm.
12" = 30 cm.


pg. 17 Washer fluid reservoir, Rear fog lights


Washer fluid reservoir
The washer fluid reservoir for the windshield and tailgate washer (wagon) is located in the engine compartment and holds approx. 0.8 US gals = 3.2 liters.
During wintertime, the reservoir should be filled with anti-freeze washer Fluid specified in section titled "Cold weather".


Rear fog lights
The rear fog lights are considerably brighter than the normal tail lights and should be used only when atmospheric conditions, such as fog, rain, snow, smoke or dust reduce the daytime or night time visibility of other vehicles to less than 500 ft. (152 meters). (The headlights must be switched on.)
Note that local regulations governing the use of these lights may vary.

pg. 18 Rear window demister, Hazard warning flasher


Rear window demister
To operate depress the switch. The indicator lamp in the switch will come on. The system will be switched off automatically after 10-15 minutes or when the starting (ignition) key is switched off. Do not place items against the inner surface of the rear window that may damage the printed circuit. Do not scrape the inner surface of the rear window glass with a hard object or use an abrasive window cleaner, otherwise damage to the printed circuit will occur.

Hazard warning flasher
The four-way flasher should be used to indicate that the vehicle has become a traffic hazard.

Note: Regulations regarding the use of the hazard warning flasher may vary from state to state.

pg. 19 Parking brake


Parking brake (hand brake)
The lever is situated between the front seats. The brake is applied to the rear wheels. The PARKING BRAKE reminder light on the instrument panel comes on whenever the parking brake lever is not fully released and the ignition is on.
Always use the parking brake (hand brake) when parked.
In order to obtain the best possible performance of the parking brake, the brake linings should be broken in. (See section titled "Break-in period".)

Seat heaters
The front seats are equipped with electrically-heated backrests and seat cushions. The switches engage the heating which then is thermostatically controlled. It switches on automatically when the temperature drops below 60°F (15°C) and switches off at approx. 95°F(35°C).




pg. 20 Cigarette lighter, Ash trays


Cigarette lighter
To operate, depress the knob fully. When the knob automatically releases, the cigarette lighter is ready for use.
The starting (ignition) switch must be ON for the cigarette lighter to function.


Ash trays
To remove the ash trays depress the center spring and remove.

pg. 21 Electrically-operated windows


Electrically operated windows (standard on certain models)
The electrically-operated windows are controlled by switches set in the door arm rests. All the windows can be controlled from the driver's arm rest as shown in the above illustration.
The starting (ignition) switch must be ON for the electrically-operated windows to function. The window is lowered if the rear part of the switch is pressed and raised if the front part of the switch is pressed.

WARNING!
Remove the starting (ignition) key from the car when children are left alone in the car.


Cut-out switch for rear-door electrically-operated windows
If the car is equipped with rear-door power windows, this function can be disabled by a switch located on the driver's door armrest.
This switch is positioned 90° in relation to the other switches.

The rear door windows can be raised or lowered with the respective door switch on the driver's door.

The rear door windows cannot be raised or lowered with the respective door switch but instead only with the corresponding switch on the driver's door.

pg. 22 Heating and ventilation

Heating system

1 TEMP
Left = cool
Right = warm

2 FLOOR
Out = no air to floor
In = full flow of air to front and rear floor

3 Defrost
Out = low volume air flow to defroster
In = full flow

4 REC (recirculation)
To be used only on cars equipped with air conditioning.
Do not use for heating.
Out = full flow of outside air
In = air is recirculated for faster cooling

5 Blower motor
Has 4 speeds and is shut completely off when the knob is turned to the left.

6 Air louvers - dash
The air flow through the louvers is decreased when the (2) and/or (3) controls are depressed.

7 Fresh air louvers - floor (except models with air conditioning)
Lever placed forward = louver opens
Lever placed rearward = louver closes





pg. 23 Heating and ventilation

How to . . .
. . . obtain max. heat

1 TEMP >>> WARM

2 depressed

5 FAN >>> 3(or 4)

6 All dash louvers halfway open and floor air louver closed.

. . . remove condensation
1 TEMP >>>WARM

3 DEF depressed

5 FAN >>> 3 (or 4)

6 All louvers closed as well as the floor fresh air louver.

Always keep front external inlet grille (in front of the windshield) clear of obstructions (snow, ice, etc.).

Maximum defroster action
For maximum defroster capacity at very low ambient temperatures, use the recirculation control (button depressed).
If not using air conditioning, the recirculation feature should not be used in humid climates and at temperatures about +23°F (-5°C).


Air louvers - dash
A Closed
B Open
C Directing air flow horizontally
D Directing air flow vertically


Fresh air louver - floor (except models with air conditioning)
There is a floor-directed fresh air louver on the driver and passenger sides of the vehicle (driver's side only on some models). Airflow is controlled by the lever at the center of the louver.

Lever placed forward = louver opens
Lever placed rearward = louver closes

Maximum airflow is obtained with louver fully open and the fan (blower motor) shut completely off. (The fan forces the air through the dash louvers.)

Previous Page   Next Page

Contents | Top of Page